Sludge of the Fuel-Energy and Oil-Producing Complex in the Production of Wall Ceramic Products


Article Preview

The experience of using slime wastes in the production of wall ceramic bricks is considered. The results of the investigation of clayey raw materials in the deposits of the Western Orenburg region and technogenic wastes of the fuel-energy and oil-producing complex are analyzed with an analysis of their effect on the properties of wall ceramics: density, strength, and water absorption. Based on the results of the research, optimal compositions were developed using ash and slag wastes in a composition with aluminosilicate clay raw material - loam. The influence of drill cuttings with an increased content of calcium oxide on the composition and physical and mechanical properties of wall ceramics, the effect of a composition of low-grade local clay raw materials and drill cuttings on the formation of the structure and properties of ceramic materials is shown. The analysis of the volumes of formation of ash-and-slag wastes and drill cuttings is given, which makes it possible to introduce technogenic wastes into secondary production and to expand the mineral and raw materials base for the production of ceramic bricks.



Edited by:

Dr. Denis Solovev




V. A. Guryeva et al., "Sludge of the Fuel-Energy and Oil-Producing Complex in the Production of Wall Ceramic Products", Materials Science Forum, Vol. 945, pp. 1036-1042, 2019

Online since:

February 2019




* - Corresponding Author

[1] V.G. Bokov, Technogenic resources of Russia. Raw materials for the production of building materials, ZAO «Geoinformmark». (2001) 91.

[2] V.N. Vinogradov, Economic evaluation of complex mineral raw materials, Nedra. (1978).

[3] Information on

[4] S.A. Montaev, ZH.D. Sulejmenov, Wall ceramics on the basis of composition of man-made and natural raw materials of Kazakhstan, Monograph. (2006).

[5] N.A. Kuvykin, A.G. Bubnov, V.I. Grinevich, Hazardous industrial waste, «Ivanovskij gosudarstvennyj himiko-tekhnologicheskij universitet». (2004).

[6] E.YU. Nikulina, I.A. Plaksina, V.Z. Abdrahimov, A.K. Kajrakbaev, D.A. Lobachev, E.S. Abdrahimova, Ecology of industrial production. 4 (2015) 24–28.

[7] P.I. Bozhenov, Complex use of mineral raw materials for the production of building materials, «Strojizdat». (1963) 160.

[8] M.P. EHlinzon, S.G. Vasil'kov, Fuel-containing waste industry in the production of building materials, «Strojizdat». (1980) 234.

[9] V.I. Turchaninov, Building materials from industrial waste and local raw materials of the Orenburg region, «GOU OSU». (2006) 150.

[10] D. B. Solovev, A. E. Merkusheva, Use of Portal Monitors for Detection of Technogenic Radioactive Sources in Scrap Metal, IOP Conf. Series: Materials Science and Engineering. 262 (2017) 1-7, Paper № 012198. [Online]. Available: