Papers by Author: Heui Bum Ryu

Abstract: The single crystal ingots by using a sublimation technique were grown on 6H-SiC dual-seed crystals with opposite face polarities and then SiC crystal wafers sliced from the SiC ingot were systematically investigated to find out the polarity dependence of the crystal quality. The growth rate of the SiC crystal grown in this study was about 0.2mm/hr. N-type 2’’ SiC crystals exhibiting the 4H- and 6H-SiC polytype were successfully fabricated on C-face and Si-face, respectively. The incorporation of nitrogen donors in the SiC crystals grown on the C-face seed crystal was exhibited to be higher than in SiC crystals grown on a Si-face crystal. When the SiC crystal ingot proceeded to grow, the SiC crystal region grown on the C-face seed crystal was enlarged compared to the SiC crystal region on the Si-face seed crystal.

Abstract: Extensive study of various process parameters to influence on the growth of 4H-SiC crystal has been carried out using the transformation of the 6H-SiC seed by a PVT method. The axial temperature gradients were increased throughout increasing the crucible length along growth direction in order to enhance the growth rate and transformed crystal yield. The N2/Ar gas ratio used during the crystal growth related with carrier concentration/mobility of grown crystal. In the initial stage of growth, foreign polytypes such as 6H/15R were observed on 6H-SiC seed crystal but 4H crystals were entirely grown after the process optimization. While the typical absorption spectrum of SiC seed crystal indicated that the SiC polytype was the 6H-SiC with fundamental absorption energy of about 3.02eV, absorption spectrum of grown SiC crystal exhibited 4H-SiC with fundamental absorption energy of about 3.26eV. The entirely transformed SiC region exhibited lower micropipe density than 6H/4H transition region.