In Situ Transesterification of Sewage Sludge for Biodiesel Production

Abstract:

To develop new clean energy has become an urgent task for many countries forced by the energy and environment crisis. To make biodiesel from sewage sludge is one of the solutions. In this study, biodiesel production from sewage sludge by in situ transesterification was discussed. The solvent is methanol and catalyst is sulfuric acid. In-situ transesterification, has many merits over conventional transesterification reaction such as it simply the procedure by skipping the step of lipid extraction and as a result cost can be saved. That is, the steps — sludge dissolved, lipid extraction and transesterification reactions — take place simultaneously. Methanol acts as an extraction solvent and as an esterification reagent as well. Experiments were conducted to determine the optimal parameters of in-situ transesterification for maximizing the yield of biodiesel, which are methanol to sludge mass ratio, acid concentration and temperature. The optimum synthesis condition was determined by orthogonal test L₁₆ (4³), and it was found that an optimum biodiesel yield can be obtained from sewage sludge by in-situ transesterification (16.6%) at methanol to sludge mass ratio 10:1(w/w), H₂SO₄ concentration 5% (v/v), and temperature 65°C. Temperature, H₂SO₄ concentration, and methanol to sludge mass ratio in sequence had significant influence on FAMEs yield. The FAMEs in the product were analyzed by GC-MS and the purity can be higher than 96%.

• Periodical: Applied Mechanics and Materials (Volume 768)
• Pages: 520-525
• DOI: https://doi.org/10.4028/www.scientific.net/AMM.768.520
• Online since: June 2015
• Authors: Fen Fen Zhu*, Juan Juan Qi, Xiang Wei, Lu Yao Zhao, Yi Qun Xiong
• Keywords: Biodiesel, In Situ Transesterification, Sewage Sludge

References

[1] Wang Hongyan, Li Jingmin, Zhao Qun, Lin Yingji, Resources and development of new energy in China, Acta Petrolei Sinica. 30(2009)469-474.

[2] Nelson, R.G., Schrock, M.D., Energetic and economic feasibility associated with the production, processing, and conversion of beef tallow to a substitute diesel fuel, Biomass Bioenergy. 30 (2006), 584-591.

DOI: 10.1016/j.biombioe.2005.09.005

[3] Meng X, Yang J, et al, Biodieselproduction from oleaginous microorganisms, Renew Energy. 34 (2008) 1-5.

[4] Wang Cunwen, Production technology of biodiesel and some examples, Chemical Industry press. (2009)1.

[5] Fukuda H, Kondo A, Noda H, Review biodiesel fuel production by transesterification of oils, J Biosci Bioeng. 92 (2001)405-416.

DOI: 10.1016/s1389-1723(01)80288-7

[6] Vasudevan P, Briggs M, Biodiesel production-current state of the art and challenges, J Ind Microbiol Biotechnol. 35(2008)421-430.

DOI: 10.1007/s10295-008-0312-2

[7] Liu B, Zhao Z, Biodiesel production by direct methanolysis of oleaginous microbial biomass, J Chem Technol Biotechnol. 82(2007)775-780.

DOI: 10.1002/jctb.1744

[8] Haas, M. J., Foglia, T. A, Alternate feedstocks and technologies for biodiesel production, In Biodiesel Handbook 2005. ( 2005) 42-61.

DOI: 10.1201/9781439822357.ch4.2

[9] Mondala A, Liang K, Toghiani H, et al, Biodiesel production by in situ transesterification of municipal primary and secondary sludges, Bioresource Technology. 100 (2009) 1203 -1210.

DOI: 10.1016/j.biortech.2008.08.020

[10] Dorado MP, Raw materials to produce low-cost biodiesel, in Biofuels Refining and Performance. (2008)107–147.

[11] Siddiquee M N, Rohani S, Lipid extraction and biodiesel production from municipal sewage sludges: A review, Renewable and Sustainable Energy Reviews. 15(2011) 1067 -1072.

DOI: 10.1016/j.rser.2010.11.029

[12] Jarde E, Mansuy L, Faure P. Organic markers in the lipidic fraction of sewage sludges, Water Reseach. 39(2005)1215 -1232.

DOI: 10.1016/j.watres.2004.12.024

[13] Xiaohu Dai, The comparison of sludge disposal technology about domestic and foreign country, Water Industry Market. 4 (2012)15-17.

[14] David M. Kargbo. Biodiesel Production from Municipal Sewage Sludges: A review, Energy Fuels. 24 (2010) 2791–2794.

DOI: 10.1021/ef1001106

[15] Gina Hincapié, Fanor Mondragón, et al, Conventional and in situ transesterification of castor seed oil for biodiesel production, Fuel. 90 (2011) 1618-1623.

DOI: 10.1016/j.fuel.2011.01.027

[16] El-Mashad HM, Zhang R, Avena-Bustillos RJ, A two-step process for biodiesel production from salmon oil, Biosyst Eng . 99(2008)220-227.

DOI: 10.1016/j.biosystemseng.2007.09.029

[17] Dufreche S, Hernandez R, French T, et al, Extraction of lipids from municipal wastewater plant microorganisms for production of biodiesel, J Amer Oil Chem Soc. 84 (2007)181-187.

DOI: 10.1007/s11746-006-1022-4

[18] Emmanuel Revellame, Rafael Hernandez, William French, et al, Biodiesel from activated sludge through in situ transesterification, J Chem Technol Biotechnol. 85(2010) 614- 620.

DOI: 10.1002/jctb.2317

[19] Isbell TA, Kleiman R, et al. Acid-catalyzed condensation of oleic acid into estolides and polyestolides. J Am Oil Chem Soc, 1994, 71: 169-174.

DOI: 10.1007/bf02541552

[20] Zerkowski JA, Estolides: From structure and function to structured and functionalized. Lipid Technol, 2008, 20: 253-256.

DOI: 10.1002/lite.200800066