Laboratory Tests on Masonry Vaults with Backfill Strengthened at the Extrados

Abstract:

This paper deals with the experimental behavior of two masonry vaults strengthened externally with a composite material. Thickness, internal span and rise of the vaults were 120 mm, 2000 mm and 730 mm, respectively. Masonry was made of solid clay bricks and lime mortar. An alkali-resistant coated glass fiber grid embedded in a cement-based matrix was used as strengthening material. The tensile strength of the glass grid as specified by its manufacturers was about 45kN/m. Both of the tested vaults were strengthened at their extrados. Expanded clay aggregate or lightweight concrete were used as a backfill. The vaults were tested under monotonic vertical loads applied at a quarter span. The main aim of the research presented here was to develop a strengthening method acceptable for vaults with frescoes, to determine the load-carrying capacity and to examine failure modes of the tested specimens. The results of the tests show that observed failure modes depend on the backfill configuration.

• Periodical: Key Engineering Materials (Volume 624)
• Pages: 510-517
• DOI: https://doi.org/10.4028/www.scientific.net/KEM.624.510
• Online since: September 2014
• Authors: Łukasz Hojdys*, Piotr Krajewski
• Keywords: Arches, Backfill, Composite, Experimental Tests, Masonry, TRM, Vaults

References

[1] M.R. Valluzzi, M. Valdemarca, C. Modena, Behavior of brick masonry vaults strengthened by FRP laminates, J. Compos. Constr., 5(3) (2001) 163–169.

DOI: 10.1061/(asce)1090-0268(2001)5:3(163)

[2] P. Foraboschi, Strengthening of masonry arches with Fiber-Reinforced Polymer strips, J. Compos. Constr., 8(3) (2004) 191–202.

DOI: 10.1061/(asce)1090-0268(2004)8:3(191)

[3] S. Briccoli Bati, S. Rovero, U. Tonietti, Strengthening masonry arches with composite materials, J. Compos. Constr., 11(1) (2007) 33–41.

DOI: 10.1061/(asce)1090-0268(2007)11:1(33)

[4] D. Oliveira, I. Basilio, P. Lourenco, Experimental Behavior of FRP Strengthened Masonry Arches, J. Compos. Constr., 14(3) (2010) 312–322.

DOI: 10.1061/(asce)cc.1943-5614.0000086

[5] A. Borri, P. Casadei, G. Castori, S. Ebaugh, Experimental analysis of masonry arches strengthened by innovative composite laminates, in 10th North American Masonry Conference (2007).

[6] Ł. Bednarz, A. Górski, J. Jasieńko, E. Rusiński, Simulations and analyses of arched brick structures, Autom. Constr., 20 (2011) 741–754.

DOI: 10.1016/j.autcon.2011.01.005

[7] Ł. Hojdys, The influence of strengthening with fiber reinforced composites on load bearing capacity of masonry vaults (in polish), PhD-Thesis, Cracow University of Technology, (2010).

[8] L. Garmendia, J.T. San-José, D. García, P. Larrinaga, Rehabilitation of masonry arches with compatible advanced composite material, Constr. Build. Mater., 25 (2011) 4374-4385.

DOI: 10.1016/j.conbuildmat.2011.03.065

[9] Ł. Hojdys, P. Krajewski, Behavior of masonry arches strengthened with TRM, in 7th International Conference on Arch Bridges (ARCH'13) 2013 739-746.

[10] R. Royles, A.W. Hendry, Model tests on masonry arches, Proc. Inst. Civ. Eng. Part 2 Res. Theory, 91 (1991) 299–321.

[11] J. Page, Masonry arch bridges, HMSO, (1993).

[12] C.A. Fairfield, D. Ponniah, Model tests to determine the effect of fill on buried arches, Proc. Inst. Civ. Eng. Struct. Build., 104 (1994) 471–482.

DOI: 10.1680/istbu.1994.27205

[13] T.G. Hughes, M.C.R. Davies, P.R. Taunton, The influence of soil and masonry type on the strength of masonry arch bridges, in 2nd International Arch Bridge Conference, (1998) 321–330.

DOI: 10.1201/9781003078494-46

[14] P. Krajewski, Analysis of the backfill material influence on load carrying capacity of masonry vaults (in polish), PhD-Thesis, Cracow University of Technology, (2010).

[15] P. Callaway, M. Gilbert, C.C. Smith, Influence of backfill on the capacity of masonry arch bridges, Proc. Inst. Civ. Eng. Bridge Eng. 165(3) (2012) 147-157.

DOI: 10.1680/bren.11.00038

[16] P. Krajewski, Ł. Hojdys, Experimental studies on buried barrel vaults, submitted to Int. J. Archit. Herit. in (2013).

[17] Ł. Hojdys, P. Krajewski, Experimental tests on strengthened and unstrengthened masonry vault with backfill, in 8th International Conference on Structural Analysis of Historical Constructions (SAHC 2012) 668-674.