Raman and Photoluminescence Spectroscopy of Nanocrystalline Diamond Films Grown by Hot Filament CVD

Abstract:

Nanocrystalline diamond films were grown by hot filament chemical vapour deposition (HFCVD) in a mixture of methane and hydrogen gases. Three straight parallel wires filament configuration were used in the HFCVD system for the deposition of the films studied in this work. The deposition pressure for the growth of diamond films in this hot filament chemical vapour deposition (HFCVD) reactor have been optimized to be at 20 torr with the methane and hydrogen flow-rates fixed at 2 and 200 sccm respectively. The films studied in this work were grown at low deposition pressures of 2 and 5 torr using the same gas flow-rates used for the optimized diamond film growth including an additional film grown at pressure of 5 mbar with the methane flow-rate reduced to 1 sccm. The morphology showed the formation of closed packed diamond grains for the film grown at 5 torr with methane and hydrogen flow-rates fixed at 2 and 200 sccm. Decrease in pressure and methane flow-rate produced significant changes to the morphology of the diamond grains formed. X-ray diffraction showed that diamond phase phases were dominant in the films deposited at higher pressure. Raman and photoluminescence (PL) spectral analysis were performed using spectra acquired at 325 and 514 nm excitation energies. Raman analysis revealed that increase in deposition pressure from 2 to 5 Torr resulted in the transformation of the film structure from diamond-like-carbon to nanocrystalline diamond structure. UV excitation produced high PL emission intensity at 2.1 eV and the PL intensity was highest for the films deposited at the lowest pressure. Visible excitation on the other hand produced low intensity broad PL emission for all the films between 1.2 and 2.5 eV and the PL intensity was high for the films deposited at the highest deposition pressure.

• Periodical: Advanced Materials Research (Volume 501)
• Pages: 271-275
• DOI: https://doi.org/10.4028/www.scientific.net/AMR.501.271
• Online since: April 2012
• Authors: S.A. Rahman, M.Z. Othman, P.W. May
• Keywords: Hot-Filament CVD, Morpholoy, Nanocrystalline Diamond, Photoluminescence (PL), Raman Spectroscopy

References

[1] C. J. Wort, R. S. Balmer,"Diamond as an electronic material", Mater. Today 11(1-2) (2008) 22.

[2] M. Roy, S. Ghodbane, T. Koch. A. Pauschitz, D. Steinmuller-Nehl, A. Tomala, C. Tomastik, F. Franek, "Tribological investigation of nanocrystalline diamond films at low load under different tribosystems", Diamond Relat. Mater. 20(2011) 573.

DOI: 10.1016/j.diamond.2011.02.012

[3] R. Haubner, B. Lux, "Diamond growth by hot-filament chemical vapour deposition: state of the art", Diamond Relat. Mater. 2 (1993) 1277.

DOI: 10.1016/0925-9635(93)90008-p

[4] N. Govindaraju. R.N. Singh, "Processing of nanocrystalline diamond thin films for thermal management of wide-bandgap semiconductor electronics", Mat. Sci. & Eng. B 176 (14) (2011) 1058.

DOI: 10.1016/j.mseb.2011.05.042

[5] H. Pang, X. Wang, G. Zhang, H. Chen, G. Lv, S. Yang, "Characterization of diamond-like carbon films SEM, XRD and Raman spectroscopy", App. Surf. Sc. 256 (2010) 6403.

DOI: 10.1016/j.apsusc.2010.04.025

[6] B. Wen, J. Zhao, T. Li and C. Dong, "Crystal structure of n-diamond: experimental and simulation studies", New Journal of Physics 8(2006) 62.

[7] S.M Leeds, T.J. Davis, P.W. May. C.D.O. Pickard and M.N. R. Ashfold, "Use of different excitation wavelengths for analysis of CVD diamond by laser Raman spectroscopy", Diamond & Related Materials 7(2-5)(1998) 233.

DOI: 10.1016/s0925-9635(97)00261-6

[8] K.E. Spear, J. Am., "Diamond ceramic coating of the future", Ceram. Soc. 72(2) (1989) 171.

[9] H. Kuzmany, R. Pfeiffer, N. Salk, B. Gunther, "The mystery of 1140cm-1 Raman line in nanocrystalline diamond films", Carbon 42 (2004) 911.

DOI: 10.1016/j.carbon.2003.12.045

[10] L. Wang, Q, Zeng, J. Huang, R. Xu, J. Zhang, Y. Xia, "Influence of diamond grain size on the electrical properties of nano-crystalline diamond detectors", Thin Solid Films 520 (2011) 717-720.

DOI: 10.1016/j.tsf.2011.04.160

[11] L. Bergman, M. T. Mclure, J. T. Glass, R. Nemanich, "The origin of broad band luminescence and the effect of nitrogen doping on the optical properties of diamond films", J. Appl. Phys. 76 (5) (1194) 3020.

DOI: 10.1063/1.357508

[12] K. Fabisiak, W. Bala, K. Paprocki, M. Szreiber, C. Uniszkiewicsz, "Broad band photoluminescence studies of diamond layers grown by hot-filament CVD" Optical Materials 31 (2006) 1873.

DOI: 10.1016/j.optmat.2009.02.020