Effect of Preparation Conditions on Heavy Metal Adsorption Characteristics of Activated Carbon Prepared from Non-Fibrous Material of Pineapple Leaves

Abstract:

Activated carbon can be prepared from any kind of hydrocarbon-based material, and that from agricultural wastes is attractive for many reasons. The use of natural fiber in various industries gives rise to some associated waste streams. In this work, activated carbon, produced from the non-fibrous material waste from pineapple leaf fiber production, was studied for its heavy metal adsorption behavior. The material was carbonized at different temperatures and chemical activation was carried out using phosphoric acid. Pore size and pore volume of the adsorbent were determined using the Brunauer–Emmett–Teller (BET) method, and surface morphology by scanning electron microscopy (SEM). Fourier Transform Infrared Spectrophotometry (FT-IR) was used to identify the functional groups in the material. It was found that the surface area, pore volume and morphology of the surface depended on the carbonization temperature. The best adsorbent was obtained using a carbonization temperature of 500 °C and an activation temperature of 600 °C. Adsorptions of several heavy metals were studied over the concentration range of 4 - 800 mg L⁻¹ and pH 2-10. The optimum amount of the adsorbent was found to be 1.20 g per 100 ml of solution, removing up to 92.67% of lead ions. The adsorption behaviour was closer to the Freundlich isotherm than to the Langmuir isotherm. So this waste could be a useful bio-source for activated carbon production.

• Periodical: Key Engineering Materials (Volume 824)
• Pages: 114-120
• DOI: https://doi.org/10.4028/www.scientific.net/KEM.824.114
• Online since: October 2019
• Authors: Chutima Khumnuan, Amornrat Moungon, Karine Mougin, Pornsawan Amornsakchai*
• Keywords: Activated Carbon, Adsorption, Heavy Metals, Lead

References

[1] A. Bhatnagar, M. Sillanpää. Utilization of agro-industrial and municipal waste materials as potential adsorbents for water treatment—A review. Chem. Eng. J. 157 (2010) 277–296.

DOI: 10.1016/j.cej.2010.01.007

[2] D. Mohan, K.P. Singh, V.K. Singh. Wastewater treatment using low cost activated carbons derived from agricultural byproducts—A case study. J. Hazard. Mater. 152 (2008) 1045–1053.

DOI: 10.1016/j.jhazmat.2007.07.079

[3] S.D. Gisi, G. Lofrano, M. Grassi, M. Notarnicola. Characteristics and adsorption capacities of low-cost sorbents for wastewater treatment: A review. Sustainable Materials and Technologies 9 (2016) 10–40.

DOI: 10.1016/j.susmat.2016.06.002

[4] R. Wang, C. Shin, S. Park, J.S. Park, D. Kim, L. Cui, M. Ryu. Removal of lead (II) from aqueous stream by chemically enhanced kapok fiber adsorption. Environ. Earth. Sci. 72 (2014) 5221–5227.

DOI: 10.1007/s12665-014-3804-6

[5] S.R. Shukla, R.S. Pai. Removal of Pb(II) from solution using cellulose-containing materials. J. Chem. Technol. Biotechnol. 80 (2005) 176–183.

DOI: 10.1002/jctb.1176

[6] N. Kengkhetkit, T. Amornsakchai. Utilisation of pineapple leaf waste for plastic reinforcement: 1. A novel extraction method for short pineapple leaf fiber. Ind. Crops. Prod. 40 (2012) 55–61.

DOI: 10.1016/j.indcrop.2012.02.037

[7] N. Kengkhetkit, T. Amornsakchai. A new approach to 'Greening', plastic composites using pineapple leaf waste for performance and cost effectiveness. Mater. Des. 55 (2014) 292–299.

DOI: 10.1016/j.matdes.2013.10.005

[8] B.S. Girgis, E. Smith, M.M. Louis, A.H.A. El-Hendawy. Pilot production of activated carbon from cotton stalks using H3PO4. J. Anal. Appl. Pyrol. 86 (2009) 180-184.

DOI: 10.1016/j.jaap.2009.06.002

[9] S. Mopoung, P. Amornsakchai. Microporous activated carbon fiber from pineapple leaf fiber by H3PO4 activation. Asian J. Sci. Res. 9 (2016) 24-33.

DOI: 10.3923/ajsr.2016.24.33

[10] L. Lin, S.R. Zhai, Z.Y. Xiao, Y. Song, Q.D. An, X.W. Song. Dye adsorption of mesoporous activated carbons produced from NaOH-pretreated rice husks. Bioresour. Technol. 136 (2013) 437-443.

DOI: 10.1016/j.biortech.2013.03.048

[11] M.Y. Abdelnaeima, I.Y. El Sherif, A.A. Attia, N.A. Fathy, M.F. El-Shahat. Impact of chemical activation on the adsorption performance of common reed towards Cu(II) and Cd(II). Int. J. Miner. Process. 157 (2016) 80–88.

DOI: 10.1016/j.minpro.2016.09.013