Characterization of Precipitation Evolution in a Zn-Added Al-Mg-Si-Cu Alloy during Artificial Aging at 170 °C

Abstract:

A Zn-added Al-Mg-Si-Cu alloy during aging at 170 °C up to 34 h exhibits an interesting age-hardening effect. Small clusters, enriched in Mg and Si, are present in the sample after 0.25 h aging. The β′′ phase is dominant with the peak hardness of 135 HV after aging of 8 h. A decrease in hardness of the alloy occurs with the aging time increasing to 34 h, due to the coarsening of β′′ phase. It is also found that the Cu-containing L phase co-exists with the β′′ phase at this aging condition. The quantitative solute concentrations of the matrix show that the formation of clusters is consistent with the slight lower contents of Mg, Si and Cu compared with the alloy chemical composition, and the present of β′′ and L phase is associated with the further partitioning of Mg, Si and Cu from the Al matrix into the precipitates. No Zn-rich clusters and precipitates are observed and the Zn concentration in matrix has no significant change during aging for up to 34 h. This result means that the major of Zn remains in the matrix as aging continues.

• Periodical: Materials Science Forum (Volume 941)
• Pages: 961-966
• DOI: https://doi.org/10.4028/www.scientific.net/MSF.941.961
• Online since: December 2018
• Authors: Shang Zhu, Zhi Hui Li*, Li Zhen Yan, Xi Wu Li, Shu Hui Huang, Hong Wei Yan, Yong An Zhang, Bai Qing Xiong
• Keywords: 3DAP, Al-Mg-Si-Cu Alloy, Precipitation Evolution, TEM, Zn Addition

References

[1] G.A. Edwards, K. Stiller, G.L. Dunlop, M.J. Couper, The precipitation sequence in Al-Mg-Si alloys, Acta Mater. 46 (1998) 3893-3904.

DOI: 10.1016/s1359-6454(98)00059-7

[2] S. Pogatscher, H. Antrekowitsch, H. Leitner, T. Ebner, P.J. Uggowitzer, Mechanisms controlling the artificial aging of Al-Mg-Si Alloys, Acta Mater. 59 (2011) 3352-3363.

DOI: 10.1016/j.actamat.2011.02.010

[3] V. Fallah, A. Korinek, N. Ofori-Opoku, B. Raeisinia, M. Gallerneault, N. Provatas, S. Esmaeili, Atomic-scale pathway of early-stage precipitation in Al-Mg-Si alloys, Acta Mater. 82 (2014) 457-467.

DOI: 10.1016/j.actamat.2014.09.004

[4] M. Murayama, K. Hono, W.F. Miao, D.E. Laughlin, The effect of Cu additions on the precipitation kinetics in an Al-Mg-Si alloy with excess Si, Metall. Mater. Trans. A, 32 (2001) 239-246.

DOI: 10.1007/s11661-001-0254-z

[5] R. Vissers, M.A.V. Huis, J. Jansen, H.W. Zandbergen, C.D. Marioara, S.J. Andersen, The crystal structure of the β'' phase in Al-Mg-Si alloys, Acta Mater. 46 (1998) 3283-3298.

DOI: 10.1016/j.actamat.2007.02.032

[6] C. Ravi, C. Wolverton. First-principles study of crystal structure and stability of Al-Mg-Si-(Cu) precipitates, Acta Mater. 52 (2004) 4213-4227.

DOI: 10.1016/j.actamat.2004.05.037

[7] R. Vissers, M.A.V. Huis, J. Jansen, H.W. Zandbergen, C.D. Marioara, S.J. Andersen, The crystal structure of the β' phase in Al–Mg–Si alloys, Acta Mater. 55 (2007) 3815-3823.

DOI: 10.1016/j.actamat.2007.02.032

[8] M.A.V. Huis, J.H. Chen, H.W. Zandbergen, M.H.F. Sluiter, Phase stability and structural relations of nanometer-sized, matrix-embedded precipitate phases in Al–Mg–Si alloys in the late stages of evolution, Acta Mater. 54 (2006) 2945-2955.

DOI: 10.1016/j.actamat.2006.02.034

[9] R.K.W. Marceau, A.D. Vaucorbeil, G. Sha, S.P. Ringer, W.J. Poole, Analysis of strengthening in AA6111 during the early stages of aging: Atom probe tomography and yield stress modelling, Acta Mater. 61 (2013) 7285-7303.

DOI: 10.1016/j.actamat.2013.08.033

[10] A.K. Gupta, D.J. Lloyd, S.A. Court, Precipitation hardening in Al-Mg-Si alloys with and without excess Si, Mater. Sci. Eng. A 316 (2001) 11-17.

DOI: 10.1016/s0921-5093(01)01247-3

[11] L.P. Ding, Z.H. Jia, Z.Q. Zhang, R.E. Sanders, Q. Liu, G. Yang, The natural aging and precipitation hardening behaviour of Al-Mg-Si-Cu alloys with different Mg/Si ratios and Cu additions, Mater. Sci. Eng. A 627 (2015) 119-126.

DOI: 10.1016/j.msea.2014.12.086

[12] C.D. Marioara, S.J. Andersen, T.N. Stene, H. Hasting, J. Walmsley, A.T.J. Van helvoort, R. Holmestad, The effect of Cu on precipitation in Al–Mg–Si alloys, Philos. Mag. 87 (2007) 3385-3413.

DOI: 10.1080/14786430701287377

[13] L. Ding, Z. Jia, Y. Liu, Y. Weng, Q. Liu, The influence of Cu addition and pre-straining on the natural aging and bake hardening response of Al-Mg-Si alloys, J. Alloy Compd. 688 (2016) 362-367.

DOI: 10.1016/j.jallcom.2016.07.066

[14] G. Sha, A. Cerezo, Early-stage precipitation in Al–Zn–Mg–Cu alloy (7050), Acta Mater. 52 (2004) 4503-4516.

DOI: 10.1016/j.actamat.2004.06.025

[15] L.K. Berg, J. Gjønnes, V. Hansen V, X.Z. Li, M. Knutson-Wedel, G. Waterloo, D. Schryvers, L.R. Wallenberg, GP-zones in Al–Zn–Mg alloys and their role in artificial aging, Acta Mater. 49 (2001) 3443-3451.

DOI: 10.1016/s1359-6454(01)00251-8

[16] K. Hono, Atom probe microanalysis and nanoscale microstructures in metallic materials, Acta Mater. 47 (1999) 3127-3145.

DOI: 10.1016/s1359-6454(99)00175-5

[17] L.T. Stephenson, M.P. Moody, P.V. Liddicoat, S.P. Ringer, New techniques for the analysis of fine-scaled clustering phenomena within atom probe tomography (APT) data, Microsc. Microanal. 13 (2007) 448-63.

DOI: 10.1017/s1431927607070900

[18] S. Esmaeili, X. Wang, D.J. Lloyd, W.J. Poole, On the precipitation-hardening behavior of the Al−Mg−Si−Cu alloy AA6111, Metall. Mater. Trans. A 34 (2003) 751-763.

DOI: 10.1007/s11661-003-0110-4

[19] Y.H. Cai, C. Wang, J.S. Zhang, Microstructural characteristics and aging response of Zn-containing Al-Mg-Si-Cu alloy, Int. J. Min. Met. Mater. 20 (2013) 659-664.

DOI: 10.1007/s12613-013-0780-x

[20] M.X. Guo, Y. Zhang, X.K. Zhang, J.S. Zhang, L.Z. Zhuang, Non-isothermal precipitation behaviors of Al-Mg-Si-Cu alloys with different Zn contents, Mater. Sci. Eng. A 669 (2016) 20-32.

DOI: 10.1016/j.msea.2016.05.060

[21] X.P. Ding, H. Cui, J.X. Zhang, H.X. Li, M.X. Guo, Z. Lin, L.Z. Zhuang, J.S. Zhang, The effect of Zn on the age hardening response in an Al-Mg-Si alloy, Mater. Des. 65 (2015) 1229-1235.

DOI: 10.1016/j.matdes.2014.09.086