Comparison of Surfactant Performance Using D-LIMONENE According to EO(Ethylene Oxide) Mole Number for Cleaning the Fish Cake Production Process

Young Soo Na; Hwa Soo Lee; Jin Gyu Chang; Kap Seop Jeong; Dae Myung An

doi:10.4028/www.scientific.net/AMM.872.155

Paper Titles

Analysis of Development Trends in Low Energy Advanced Convergence Building Technology
p.125

Numerical Simulation of Precast Pile Caps Reinforced Concrete
p.130

Geotechnical Study on the Use of Sanitized Sewage Sludge in Cover Layers of Solid Waste Landfills
p.143

Synthesis of MoS₂/Graphene Hybrid for Electrochemical Detection and Catalytic Reduction of 4-Nitrophenol
p.149

Comparison of Surfactant Performance Using D-LIMONENE According to EO(Ethylene Oxide) Mole Number for Cleaning the Fish Cake Production Process
p.155

Fabrication of Sulfonated Bamboo Charcoal-Chitosan (sBC-CS) Hybrid and its Applications for Reinforcement of Styrene-Butadiene Rubber
p.160

Study on the Preparation and Characterization of Carboxyl Terminated Poly(L-Lactic Acid) (PLLA) Prepolymers
p.165

A ZnS-Nanoparticle-Label-Based Electrochemical Codeine Sensor
p.173

Copper Doping TiO₂ Nanotube Arrays Loaded with Hydrophilic and Hydrophobic Drugs and its Release
p.178

HomeApplied Mechanics and MaterialsApplied Mechanics and Materials Vol. 872Comparison of Surfactant Performance Using...

Comparison of Surfactant Performance Using D-LIMONENE According to EO(Ethylene Oxide) Mole Number for Cleaning the Fish Cake Production Process

Abstract:

The cleaning efficiency of EO (ethylene oxide) 8~9 mole was about 78-80%, it is the best. The highest cleaning efficiency for each EO mole concentration is as follows. The cleaning efficiency was 97% in the surfactant of 4.8% EO 5 mole, the cleaning efficiency was 97% in the surfactant of 7.7% EO 8 mole, and 68% in the surfactant of 7.7% EO 10 mole. The cleaning efficiency was measured using a surfactant with various EO mole. All detergents were tested at 20% surfactant concentration and EO 8 and EO 9 showed the highest cleaning power. In experiments using 8 mole of EO surfactant NPE8, the highest cleaning power was obtained at surfactant concentration of 7.7%. To determine the cause of this, the electrical conductivity of the solution was measured at the concentration of NPE8 at 1.6%, 4.8%, 7.7%, 14.4% and 20%, respectively. After washing the test plate with NPE8, the detergent remaining on the surface of the test plate was analyzed by FT / IR, and it was found that the detergent did not remain.