Enhanced Chromium Recovery from Tannery Waste by Acid-Alkali Reaction in China

Abstract:

Leather processing is an important industry in China, and the discharge of chromium waste has been severely circumscribed. Though traditional processes for treating chromium waste have been widely used in tannery plants, technology adopting high efficiency and economic simultaneously is deficient. In order to develop an economic treatment for tannery waste, a mixed alkali of sodium hydroxide and magnesium oxide and diluted mineral acids were tested to improve the sedimentation effect of trivalent chromium from tannery wastewater. The results showed that the most feasible alkali was a mixture of sodium hydroxide and magnesium oxide with a mass ratio of 5:1 to balance the cost performance. The high chromium removal as 99.1% was obtained with a mixed alkali dosage only 0.2 g/L at pH 9.5, with a very low Cr-sludge yield. The effects of various factors on the extraction of trivalent chromium from Cr-sludge using mineral acids were investigated further more, and the results indicated that the feasible condition for chromium recovery from wet chromium sludge was as follows: 4% sulfuric acid as the leaching acid, chromium sludge (dry weight) load 23.55 g/L, extraction time 60 min, and reaction temperature 30°C. A chromium recovery of 20.86 mg/g was obtained under the feasible condition with a recovery rate of 91.8%. The method developed in the present study provided an effective solution to balance the cost performance for tannery waste treatment.

• Periodical: Advanced Materials Research (Volume 878)
• Pages: 185-193
• DOI: https://doi.org/10.4028/www.scientific.net/AMR.878.185
• Online since: January 2014
• Authors: Huai Li, Jian Zheng Li, Zi Fang Chi
• Keywords: Acid-Alkali Reaction, Chemical Precipitation, Chromium Recovery, Chromium Sludge, Tannery Wastewater

References

[1] Y.C. Sharma, Cr(VI) removal from industrial effluents by adsorption on an indigenous low-cost material, Colloid Surf. A-Physicochem. Eng. Asp. 215 (2003) 155-162.

DOI: 10.1016/s0927-7757(02)00485-5

[2] S. Langard, One hundred years of chromium and cancer: a review of epidemiological evidence and selected case reports, Am. J. Ind. Med. 17 (1990) 189-215.

DOI: 10.1002/ajim.4700170205

[3] T.C. Tsou, R.J. Lin, J.L. Yang, Mutational spectrum induced by chromium(III) in shuttle vectors replicated in human cells: Relationship to Cr(III)-DNA interactions, Chem. Res. Toxicol. 10 (1997) 962-970.

DOI: 10.1021/tx970040p

[4] L.J. Blankenship, F.C.R. Manning, J.M. Orenstein, S.R. Patierno, Apoptosis is the mode of cell-death caused by carcinogenic chromium, Toxicol. Appl. Pharm. 126 (1994) 75-83.

DOI: 10.1006/taap.1994.1092

[5] Z. Kowalski, Treatment of chromic tannery wastes, J. Hazard. Mater. 37 (1994) 137-141.

[6] G. Lofrano, E. Aydın, F. Russo, M. Guida, V. Belgiorno, S. Meric, Characterization fluxes and toxicity of leather tanning bath chemicals in a large tanning district area (IT), Water Air Soil Pollut. 8 (2008) 529-542.

DOI: 10.1007/s11267-008-9177-7

[7] G. Macchi, M. Pagano, M. Pettine, M. Santori, G. Tiravanti, A bench study on chromium recovery from tannery sludge, Water Res. 25 (1991) 1019-1026.

DOI: 10.1016/0043-1354(91)90152-g

[8] S. Avudainayagam, A. Megharaj, G. Owens, R.S. Kookana, D. Chittleborough, R. Naidu, Chemistry of chromium in soils with emphasis on tannery waste sites, Rev. Environ. Contam.T. 178 (2003) 53-91.

DOI: 10.1007/0-387-21728-2_3

[9] R.J. Bartlett, J.M. Kimble, Behavior of chromium in soils: I. Trivalent forms, J. Environ. Qual. 5 (1976) 379-383.

DOI: 10.2134/jeq1976.00472425000500040009x

[10] European Commission, EC water framework directive (2000/60/EC), Offic. J. Eur. Comm. L327 (2000) 1-72.

[11] China Leather Industry Association, Annual Report, China Leather Industry Association, Beijing, (2001).

[12] C. Fabiani, F. Ruscio, M. Spadoni, M. Pizzichini, Cr(III) slats recovery process from tannery wastewaters, Desalination 108 (1997) 183-191.

DOI: 10.1016/s0011-9164(97)00026-x

[13] D.M. Yang, Current application studies of tannery wastewater treatment process, Leath. Chem. 28(2011) 34-39.

[14] M.C. Chuan, J.C. Liu, Release behavior of chromium from tannery sludge, Water Res. 30 (1996) 932-938.

DOI: 10.1016/0043-1354(95)00227-8

[15] A. Carucci, A. Chiavola, M. Majone, E. Rolle, Treatment of tannery wastewater in a sequencing batch reactor, Water Sci. Technol. 40 (1999) 253-259.

DOI: 10.2166/wst.1999.0054

[16] A. Cassano, R. Molinari, M. Romano, E. Drioli, Treatment of aqueous effluents of the leather industry by membrane processes - A review, J. Membr. Sci. 181 (2001) 111-126.

DOI: 10.1016/s0376-7388(00)00399-9

[17] A. Cassano, R. Molinari, E. Drioli, Saving of water and chemicals in tanning industry by membrane processes, Water Sci. Technol. 40 (1999) 443-450.

DOI: 10.2166/wst.1999.0621

[18] M.A. Chaudry, S. Ahmad, M.T. Malik, Supported liquid membrane technique applicability for removal of chromium from tannery wastes, Waste Manage. 17 (1997) 211-218.

DOI: 10.1016/s0956-053x(97)10007-1

[19] J. Landgrave, A pilot plant for removing chromium from residual water of tanneries, Environ. Health Perspect. 103 (1995) 63-65.

DOI: 10.1289/ehp.95103s163

[20] Z. Song, C.J. Williams, R.G.J. Edyvean, Sedimentation of tannery wastewater, Water Res. 34 (2000) 2171-2176.

[21] A.G. Vlyssides, C.J. Israilides, Detoxification of tannery waste liquors with an electrolysis system, Environ. Pollut. 97 (1997) 147-152.

DOI: 10.1016/s0269-7491(97)00062-6

[22] W.M. Wiegant, T.J.J. Kalker, V.N. Sontakke, R.R. Zwaag, Full scale experience with tannery water management: An integrated approach, Water Sci. Technol. 39 (1999) 169-176.

DOI: 10.2166/wst.1999.0236

[23] Y. Zheng, D. Bai, Physi-chemical-biological treatment of tannery wastewater, Ind. Water Wastewater 32 (2001) 52-54.

[24] S.B. Shen, R.D. Tyagi, J.F. Blais, Extraction of Cr(III) and other metals from tannery sludge by mineral acids, Environ. Technol., 22 (2001) 1007-1014.

DOI: 10.1080/09593332208618216

[25] Z.R. Guo, G.M. Zhang, J.D. Fang, X.D. Dou, Enhanced chromium recovery from tanning wastewater, J. Clean. Prod. 14 (2006) 75-79.

DOI: 10.1016/j.jclepro.2005.01.005

[26] T. Panswad, O. Chavalparit, Y. Sucharittham, S. Charoenwisedsin, A bench scale study on chromium recovery from tanning wastewater, Water Sci. Technol. 31 (1995) 73-81.

DOI: 10.2166/wst.1995.0346

[27] A.E. Greenberg, Standard methods for the examination of water and wastewater, 19th ed. ed., American Public Health Association, Washington D C, (1995).

[28] J.B. Wei, F. Wu, Environmental monitoring handbook, Chemical Industry Press, Beijing, (2006).

[29] F. Jorand, F. Zartarian, F. Thomas, J.C. Block, J.Y. Bottero, G. Villemin, V. Urbain, J. Manem, Chemical and structural (2D) linkage between bacteria within activated sludge flocs, Water Res. 29 (1995) 1639-1647.

DOI: 10.1016/0043-1354(94)00350-g

[30] D. Rai, B.M. Sass, D.A. Moore, Chromium (III) hydrolysis constants and solubility of chromium (III) hydroxide, Inorg. Chem. 26 (1987) 345-349.

DOI: 10.1021/ic00250a002