Design and Analysis of Low-Cost and Efficient SEPIC Converter for Affordable Solar Water Pump in Ethiopia

Abstract:

Abstract. Smallholder farms provide a significant share of the world's food supply. Smallholder farmers can cultivate crops more consistently throughout the year when using solar water pumps, which offer a dependable source of irrigation. However, the upfront capital cost and efficiency are major barriers to widespread adoption. This paper aimed to design a cost-effective and efficient DC-DC converter for small-scale irrigation farming in the Dangishta, Amhara region of Ethiopia, focusing on a direct solar water pump system using a SEPIC-based DC-DC converter. The system directly supplies power to a 100 W/24 V brushless DC pump, with a 120 W/24 V/5 A optimized SEPIC converter. A PLECS simulation was conducted to understand the converter's operation. The prototype design considered enhanced power handling capabilities using the paralleling method. The power switches are controlled by a digital circuit based on the RP2040 microcontroller, which generates PWM signals with a fixed duty cycle at 100 kHz. The average material cost of the converter was significantly minimized to approximately $15. Experimental tests showed an efficiency of 93.5% and an average temperature of 31°C, making it a promising solution for sustainable agriculture in resource-constrained environments.Keywords— Smallholder farms, Low-cost, SEPIC converter, Solar water pump, PLECS

• Periodical: International Journal of Engineering Research in Africa (Volume 72)
• Pages: 47-69
• DOI: https://doi.org/10.4028/p-3aNeSp
• Online since: December 2024
• Authors: Minyahil Tanashu*, Tassew Tadiwos, Amare Kassaw, Seifu Admasu, Noam Ezra, Teng Long, Lara Allen, Elizabeth M. Tennyson, Sam Stranks, Tefera Terefe
• Keywords: Low Cost, PLECS, SEPIC Converter, Smallholder Farms, Solar Water Pump

References

[1] IRENA, Renewable power-generation costs in 2022, International Renewable Energy Agency, Abu Dhabi, (2023)

[2] Maney Ayalew, Getachew S. Tibba, Performance and Cost Comparison of Photovoltaic and Diesel Pumpin Systems: In Central Rift Valley of Ethiopia, https://doi.org/10.46592/turkager.1272864, 2023, 4(1), 73-90

DOI: 10.46592/turkager.1272864

[3] Girma M, Assefa A and Molinas M, Feasibility study of a solar photovoltaic water pumping system for rural Ethiopia. AIMS Enviromental Science, 2(32): 697-717

DOI: 10.3934/environsci.2015.3.697

[4] Aleksandar Ašonja1, Jasmina Pekez, Nenad Janjić3, Danilo Mikić4, The Validity for the Application of Solar Energy in Irrigation of Perennial Plants in Fruit Growing in the Republic Of Serbia Applied Engineering Letters Vol. 1, No 3, 85‐90 (2016)

[5] Z. Zemarku, M. Senapathy, and E. Bojago, Determinants of Adoption of Improved Dairy Technologies: The Case of Offa Woreda, Wolaita Zone, Southern Ethiopia, Adv. Agric., vol. 2022, 2022.

DOI: 10.1155/2022/3947794

[6] S.B. Awulachew, D.J. Merrey, A.B. Kamara, B. Van Koppen, F. Penning de Vries and E. Boelee, V. Koopen and A. P. De Vries, Experiences and Opportunities for Promoting Small-Scale/Micro Irrigation and Rainwater Harvesting for Food Security in Ethiopia, International Water Management Institute, Addis Ababa, (Working paper 98), 2005.

[7] L. Nigussie, N. Lefore, P. Schmitter, and A. Nicol, Gender and water technologies : Water lifting for irrigation and multiple purposes in Ethiopia, no. February 2017.

[8] E. Bryan, F. Hagos, D. Mekonnen, D. A. Gemeda, and S. Yimam, the Diffusion of Small-Scale Irrigation Technologies in Ethiopia: Stakeholder Analysis Using Net-Map, SSRN Electron. J., no. July, 2020.

DOI: 10.2139/ssrn.3657153

[9] Hailemariam Berhanua a*, Fiseha Bogalea a, Alemshet Abebe a, Mengisthu Manaye b An Economic Feasibility Study of Solar and Diesel Water Pumping Systems for Irrigation in Ethiopia: A Case Study of Kombolcha, Wollo, and Abyss. J. Engg & Comput. Vol.2, No.2, (2022)

[10] Maney Ayalew DESTAa*ID, Getachew Shunki TIBAbID, and Mubarek Mohammed ISSAaID Wariso HEYIaID, Performance and Cost Comparison of Photovoltaic and Diesel Pumping Systems: In Central Rift Valley of Ethiopia. Turkish Journal of Agricultural Engineering Research, https://doi.org/10.46592/turkager.1272864, (2023)

DOI: 10.46592/turkager.1272864

[11] P. Schmitter, K. S. Kibret, N. Lefore, and J. Barron, Suitability mapping framework for solar photovoltaic pumps for smallholder farmers in sub-Saharan Africa, Appl. Geogr., vol. 94, no. February, p.41–57, 2018.

DOI: 10.1016/j.apgeog.2018.02.008

[12] J. Čolak, S. Nikolovski, R. Kljajić, H. Glavaš, Protection Coordination of Photovoltaic Power Plant in the Time Domain. Advanced Engineering Letters, 3(1), 2024: 21-29

DOI: 10.46793/adeletters.2024.3.1.3

[13] D. Melaku and T. T. Minh, "FARMER-LED IRRIGATION MULTI-STAKEHOLDER DIALOGUES : Value Chain Approaches to Small Scale Irrigation Development," no. June 2021.

[14] J. Schnetzer and L. Pluscke, "Solar-Powered Irrigation Systems: A clean-energy, low-emission option for irrigation development and modernization," p.9, 2017.

[15] P.L.I. Policy and P. September, "Impact Assessment of Small-Scale Pump Irrigation in the Somali Region of Ethiopia," vol. 1, no. September, p.1–58, 2010.

[16] FarmAfrica, "Small-scale irrigation in Tigray, Ethiopia," 2015.

[17] L. Gevorkov, J. L. Domínguez-García, and L. T. Romero, "Review on Solar Photovoltaic-Powered Pumping Systems," Energies, vol. 16, no. 1, 2023.

DOI: 10.3390/en16010094

[18] I.H. Ibrik, "Techno-economic feasibility of energy supply of water pumping in Palestine by photovoltaic-systems, diesel generators, and electric grid," Int. J. Energy Econ. Policy, vol. 10, no. 3, p.69–75, 2020.

DOI: 10.32479/ijeep.8816

[19] S. Verma et al., "Solar PV powered water pumping system - A review," Mater. Today Proc., vol. 46, no. August 2021, p.5601–5606, 2020.

DOI: 10.1016/j.matpr.2020.09.434

[20] A. Allouhi et al., "PV water pumping systems for domestic uses in remote areas: Sizing process, simulation, and economic evaluation," Renew. Energy, vol. 132, p.798–812, 2019.

DOI: 10.1016/j.renene.2018.08.019

[21] S. Lal, P. Kumar, and R. Rajora, "Performance analysis of photovoltaic based submersible water pump," Int. J. Eng. Technol., vol. 5, no. 2, p.552–560, 2013.

[22] S. Angadi, "Comprehensive Review on Solar, Wind, and Hybrid Wind-PV Water Pumping Systems-An Electrical Engineering Perspective," CPSS Trans. Power Electron. Appl., vol. 6, no. 1, p.1–19, 2021.

DOI: 10.24295/cpsstpea.2021.00001

[23] A. Hmidet et al., Design of Efficient Off-Grid Solar Photovoltaic Water Pumping System Based on Improved Fractional Open Circuit Voltage MPPT Technique, Int. J. Photoenergy, vol. 2021, 2021.

DOI: 10.1155/2021/4925433

[24] W. E. Abd Allah and M. A. Tawfik, Design and Operating Assessment of Solar Pv Underground Water Pumping System in Upper Egypt, Misr J. Agric. Eng., vol. 36, no. 2, p.565–586, 2019.

DOI: 10.21608/mjae.2019.94684

[25] S. Kumar and S. Kumar, Solar Pv Powered Water Pumping System Using DC Motor Drive: a Critical Review, Int. J. Tech. Res. Sci., vol. 05, no. 04, p.1–8, 2020.

DOI: 10.30780/ijtrs.v05.i04.001

[26] M. Abdo, M. Ahmed Mohammed Saeed, and M. El-Saadawi, Impact of Virtual Flow Rate Meter on Brushless DC Motor Based PV-Water Pumping System (Dept. E), MEJ. Mansoura Eng. J., vol. 45, no. 4, p.9–17, 2020.

DOI: 10.21608/bfemu.2020.123899

[27] J. Ahmad, M. D. Siddique, A. Sarwar, C. H. Lin, and A. Iqbal, "A high gain noninverting DC-DC converter with low voltage stress for industrial applications," Int. J. Circuit Theory Appl., vol. 49, no. 12, p.4212–4230, 2021.

DOI: 10.1002/cta.3129

[28] M. Z. Hossain, N. A. Rahim, and J. a/l Selvaraj, "Recent progress and development on power DC-DC converter topology, control, design, and applications: A review," Renew. Sustain. Energy Rev., vol. 81, no. January 2017, p.205–230, 2018.

DOI: 10.1016/j.rser.2017.07.017

[29] V.G.R. Kummara et al., A comprehensive review of DC-DC converter topologies and modulation strategies with recent advances in solar photovoltaic systems, vol. 9, no. 1. 2020.

DOI: 10.3390/electronics9010031

[30] N. Tewari and V. T. Sreedevi, A novel single switch dc-dc converter with high voltage gain capability for solar PV based power generation systems, Sol. Energy, vol. 171, no. January, p.466–477, 2018.

DOI: 10.1016/j.solener.2018.06.081

[31] R. Reshma Gopi and S. Sreejith, "Converter topologies in photovoltaic applications – A review," Renew. Sustain. Energy Rev., vol. 94, no. May, p.1–14, 2018.

DOI: 10.1016/j.rser.2018.05.047

[32] M. Premkumar, U. Subramaniam, H. H. Alhelou, and P. Siano, Design and development of non-isolated modified SEPIC DC-DC converter topology for high-step-up applications: Investigation and hardware implementation, Energies, vol. 13, no. 15, 2020.

DOI: 10.3390/en13153960

[33] A. Azeem, M. K. Ansari, M. Tariq, A. Sarwar, M. Alam, and C. Bhartiraja, Design and Analysis of Packed U-Cell and SEPIC Converter Based Solar PV System for Grid Connection, Proc. 2018 IEEE Int. Conf. Power Electron. Drives Energy Syst. PEDES 2018, no. April, p.1–6, 2018.

DOI: 10.1109/PEDES.2018.8707714

[34] K. Uthira, R. Sandhiya, P. Iraianbu, and R. Srinivasan, Analysis and Design of Solar Power Fed DC-DC SEPIC Converter, p.3804–3811, 2018.

[35] S. Asapu and V. R, "Modified hysteresis current control of multilevel converter for grid-connected battery storage system," Mater. Today Proc., no. xx, 2021.

DOI: 10.1016/j.matpr.2021.07.290

[36] D. Murali, Steady-state behavior of a single-switch non-isolated DC-DC sepic converter topology with improved static voltage gain, J. Eur. des Syst. Autom., vol. 54, no. 3, p.445–452, 2021.

DOI: 10.18280/JESA.540307

[37] I. M. Pop-Calimanu, S. Popescu, and D. Lascu, A New SEPIC-Based DC-DC Converter with Coupled Inductors Suitable for High Step-Up Applications, Appl. Sci., vol. 12, no. 1, 2022.

DOI: 10.3390/app12010178

[38] J. Joseph, R. M. Patel and H. R. Pathak, Analysis and Comparison of DC-DC Converter Topologies for the Design and Development of a Solar Based Inverterless System, 2018 Second International Conference on Electronics, Communication and Aerospace Technology (ICECA), Coimbatore, India, 2018, pp.1429-1434.

DOI: 10.1109/ICECA.2018.8474867

[39] S. Kumar, R. Kumar and N. Singh, Performance of closed-loop SEPIC converter with DC-DC converter for solar energy system, 2017 4th International Conference on Power, Control & Embedded Systems (ICPCES), Allahabad, India, 2017, pp.1-6.

DOI: 10.1109/ICPCES.2017.8117668

[40] Dongbing Zhang, Designing A SEPIC Converter , AN-148, 2013, information available on: ti.com

[41] H. Dehbonei, S. R. Lee and H. Nehrir, Direct Energy Transfer for High Efficiency Photovoltaic Energy Systems Part I: Concepts and Hypothesis, in IEEE Transactions on Aerospace and Electronic Systems, vol. 45, no. 1, pp.31-45, Jan. 2009

DOI: 10.1109/TAES.2009.4805261

[42] Haile, A. & Gowing, John & Walker, David & Parkin, Geoff & Forsythe, Nathan & Alamirew, Demis. (2019). Can shallow groundwater sustain small-scale irrigated agriculture in sub-Saharan Africa? Evidence from N-W Ethiopia. Groundwater for Sustainable Development. 10.

DOI: 10.1016/j.gsd.2019.100290

[43] M. Verma and S. S. Kumar, Hardware Design of SEPIC Converter and its Analysis, International Conference on Current Trends towards Converging Technologies (ICCTCT), Coimbatore, India, 2018, pp.1-4.

DOI: 10.1109/ICCTCT.2018.8551052

[44] H. Moon, P. S. Mehfuz and S. Ahmad, Design and Implementation of SEPIC Converter for PV System Based Smart Home Application, 2022 1st International Conference on Sustainable Technology for Power and Energy Systems (STPES), SRINAGAR, India, 2022, pp.1-6.

DOI: 10.1109/STPES54845.2022.10006540

[45] Information on: https://www.monolithicpower.com

[46] DeNardo, N. Femia, F. Forrisi and M. Granato, SEPIC converter passive components design, 15th IEEE International Conference on Electronics, Circuits and Systems, Saint Julian's, Malta, 2008, pp.1002-1005.

DOI: 10.1109/ICECS.2008.4675025

[47] Information on https://www.advancedenergy.com

[48] A.A. Ashetehe, B. B. Gessesse, & F. Shewarega, A generalized approach for the determination of optimum tilt angle for solar photovoltaic modules with selected locations in Ethiopia as illustration examples. Scientific African, 18, e01433, 2022.

DOI: 10.1016/j.sciaf.2022.e01433

[49] M.H. Taghvaee, M.A.M. Radzi, S.M. Moosavain, Hashim Hizam, M. Hamiruce Marhaban, A current and future study on non-isolated DC–DC converters for photovoltaic applications, Renewable and Sustainable Energy Reviews, Volume 17, 2013.

DOI: 10.1016/j.rser.2012.09.023