Dynamic Piezoelectric Behavior of Lithium Niobate at High Temperature

Abstract:

High temperature piezoelectric materials have numerous potential applications, including high temperature ultrasound NDT, MEMS, sensors, or actuators. However, conventional piezoelectric materials are unsuitable for operation above 400°C. Lithium niobate (LiNbO₃) is a promising candidate because of its very high Curie temperature (approximately 1210°C) and reasonable piezoelectric coefficients. However, the piezoelectric properties are not sufficiently understood, partly due to the difficulties in characterizing this behavior at high temperature. Degradation mechanisms well below the Curie temperature, suspected to include phase transformations, oxygen loss, and excessive ionic conductivity, further deteriorate this property. In order to better understand these physical mechanisms, electrochemical impedance spectroscopy (EIS) is used to characterize monocrystalline LiNbO₃ from room temperature to 500°C, with excitations from 20 Hz to 20 MHz. An equivalent circuit model analysis, including resonant frequencies, is developed to investigate the temperature dependence of the piezoelectric behavior, as well as the mechanical elasticity and damping. Numerical values extracted from this analysis allows for numerical simulations to model device behavior.

• Periodical: Materials Science Forum (Volume 879)
• Pages: 408-412
• DOI: https://doi.org/10.4028/www.scientific.net/MSF.879.408
• Online since: November 2016
• Authors: Hector de Castilla*, Pierre Bélanger, Ricardo J. Zednik
• Keywords: Electrochemical Impedance Spectroscopy (EIS), High Temperature, Lithium Niobate, Piezoelectricity, Resonance Method

References

[1] A. Baba, C. T. Searfass, B. R. Tittmann, High temperature ultrasonic transducer up to 1000 °C using lithium niobate single crystal, Appl. Phys. Letters 97 (2010) 232901.

DOI: 10.1063/1.3524192

[2] G. Ohlendorf, D. Richter, J. Sauerwald, H. Fritze, High-Temperature Electrical Conductivity and Electromechanical Properties of Stoichiometric Lithium Niobate, Diffusion Fundamentals 8 (2008) 6. 1 – 6. 7.

[3] Y. S. Kuz'minov, Lithium Niobate Crystals, Cambridge International Science Publishing, (1999).

[4] H. Jin, S.R. Dong, J.K. Luo, W.I. Milne, Generalised Butterworth-Van Dyke equivalent circuit for thin-film bulk acoustic resonator, Electronic Letters 47 (2011) issue 7.

DOI: 10.1049/el.2011.0343

[5] B. Jaffe, W. R. Cook, H. Jaffe, Piezoelectric Ceramics, Academic press, New York, (1971).

[6] R.T. Smith, F.S. Welsh, Temperature Dependence of the Elastic, Piezoelectric, and Dielectric Constants of Lithium Tantalate and Lithium Niobate, J. Appl. Phys. 42 (1971) 2219.

DOI: 10.1063/1.1660528